|
Size: 7895
Comment:
|
Size: 15795
Comment:
|
| Deletions are marked like this. | Additions are marked like this. |
| Line 1: | Line 1: |
| How to realize X arm GR/IR alignment(from IMMT2(SR3) to ETMXY) | == [1] Clean booth == * [[https://gwdoc.icrr.u-tokyo.ac.jp/cgi-bin/private/DocDB/ShowDocument?docid=3599 | Laser Room]] * [[ https://gwdoc.icrr.u-tokyo.ac.jp/cgi-bin/private/DocDB/ShowDocument?docid=3588 | PR-area (including MCF-IFI-MMT-PRM-PR3) & BS-area (including PR2, BS, SR2) & EXC, EYC]] * [[https://gwdoc.icrr.u-tokyo.ac.jp/cgi-bin/private/DocDB/ShowDocument?docid=6447 | SR-area (including SR3, SRM, OMC) & I(XY)C & I(XY)V ]] * [[https://gwdoc.icrr.u-tokyo.ac.jp/cgi-bin/private/DocDB/ShowDocument?docid=12521 | I(XY)A ]] * [[https://gwdoc.icrr.u-tokyo.ac.jp/cgi-bin/private/DocDB/ShowDocument?docid=12522 | Pre-Clean Room for PSL/PR-area ]] * [[https://gwdoc.icrr.u-tokyo.ac.jp/cgi-bin/private/DocDB/ShowDocument?docid=12523| Kotohira FFU ULPA for mainly IEXYA, IEXYV]] * [[https://gwdoc.icrr.u-tokyo.ac.jp/cgi-bin/private/DocDB/ShowDocument?docid=12524 | MAC-2A-251DC-ULS-(dial) ]] |
| Line 3: | Line 10: |
| == [2] Heat Generators == === Corner === |
|
| Line 4: | Line 13: |
| 1. '''Enter Alignment Mode1''' | || Corner 1F |||| Items |||| O4a |||| 6/30 |||| 7/1 <<BR>> Cryocoolers Off |||| 7/6~7 <<BR>> FFU ON in OMC |||| 7/11 |||| 7/15 <<BR>> OMC TMP on|||| 7/16 |||| 7/18 <<BR>> O4 recovery || || - cooler |||| Precision Cooler |||| o(19.00) |||| → |||| o(23.50) {*} |||| o(20.00) {*} |||| → |||| → |||| → |||| o(19.00) {*} || || |||| Daikin Cooler MCF-C |||| x |||| → |||| → |||| → |||| → |||| → |||| → |||| → || || |||| Daikin Cooler BS-C |||| x |||| o {*} |||| → |||| → |||| → |||| → |||| → |||| x {*} || || |||| Daikin Cooler SR-C |||| x |||| → |||| → |||| → |||| → |||| → |||| → |||| → || || |||| Daikin Cooler IYC-C |||| x |||| → |||| → |||| → |||| → |||| → |||| → |||| → || || - light |||| Ceiling Lights A |||| 1/2 |||| → |||| → |||| → |||| → |||| → |||| → |||| → || || |||| Ceiling Lights B |||| 1/2 |||| → |||| → |||| → |||| → |||| → |||| → |||| → || || |||| Ceiling Lights C |||| 1/1 |||| → |||| → |||| → |||| → |||| → |||| → |||| → || || |||| Ceiling Lights IXC |||| 1/2 |||| → |||| → |||| → |||| → |||| → |||| → |||| → || || |||| Ceiling Lights IXA |||| 1/1 |||| → |||| → |||| → |||| → |||| → |||| → |||| → || || |||| Ceiling Lights IYC |||| 1/2 |||| → |||| → |||| → |||| → |||| → |||| → |||| → || || |||| Ceiling Lights IYA |||| 1/1 |||| → |||| → |||| → |||| → |||| → |||| → |||| → || || - heater |||| Sunrise Heater BS |||| x |||| → |||| o L1 {*} |||| x {*} |||| → |||| → |||| o L1 {*} |||| x {*} || || |||| Sunrise Heater SR2 |||| x |||| → |||| o L1 {*} |||| x {*} |||| → |||| → |||| → |||| → || || |||| Sunrise Heater OMC |||| x |||| → |||| o L2 {*} |||| o L1 {*} |||| → |||| x {*} |||| → |||| → || || |||| Sunrise Heater PR2 |||| x |||| → |||| → |||| → |||| → |||| → |||| → |||| → || || |||| Sunrise Heater DGS |||| x |||| → |||| → |||| → |||| → |||| → |||| → |||| → || || |||| Delonghi Heater MCF |||| o L2 |||| x {*} |||| → |||| → |||| → |||| → |||| → |||| o L2 {*} || || |||| Sunrise Heater EXC-A|||| o L3 |||| → |||| → |||| → |||| x {*} |||| → |||| → |||| → || || - ffu |||| SR FFUs |||| 03/?? |||| → |||| → |||| → |||| → |||| → |||| → |||| → || || |||| BS FFUs |||| 03/?? |||| → |||| → |||| → |||| → |||| → |||| → |||| → || || |||| PR FFUs |||| 04/?? |||| → |||| → |||| → |||| → |||| → |||| → |||| → || || |||| MCE FFUs |||| 01/16 |||| → |||| → |||| → |||| → |||| → |||| → |||| → || || - airdry |||| IXC-A Air Dryer |||| x |||| o {*} |||| → |||| → |||| → |||| → |||| → |||| → || || - Dehumid |||| Mitsubishi IYC-C |||| o |||| → |||| → |||| → |||| → |||| → |||| → |||| → || || |||| Mitsubishi BS-C |||| o |||| → |||| → |||| → |||| → |||| → |||| → |||| → || || |||| Iris DGS-1 |||| o |||| → |||| → |||| → |||| → |||| → |||| → |||| → || || |||| Iris DGS-2 |||| o |||| → |||| → |||| → |||| → |||| → |||| → |||| → || || |||| Nakatomi BS |||| o |||| → |||| → |||| → |||| → |||| → |||| → |||| → || |
| Line 6: | Line 44: |
| * Go to [[http://172.16.32.60/kagra_mannual/img/commissioning_doc.png|Commissioning.Doc]]. * Select "LSC_Lock" in Commissioning.Doc. * Select "request [All]" in [[http://172.16.32.60/kagra_mannual/img/gurad-LSC_LOCK.MAIN.png|LSC_Lock]]. * Select "DOWN" in [[http://172.16.32.60/kagra_mannual/img/gurad-LSC_LOCK.STATES.png|All]]. |
|| |||| Items |||| O4a |||| 6/30 |||| || || PSL Room |||| Precision Cooler #1 |||| o |||| → |||| || || |||| Precision Cooler #2 |||| x |||| → |||| || |
| Line 11: | Line 48: |
| * '''Enter Alignment Mode2''' | || |||| Items |||| O4a |||| 6/30 ||||7/3 <<BR>> Cryocoolers ON||||7/18 <<BR>> O4a Recovery|||| 7/27 <<BR>> Coolers On|| || IXC |||| TMP/Drys |||| 3 x |||| 3 o {*} |||| → |||| 3 x {*} |||| → || || |||| Ion Pump |||| 2 o |||| 2 x {*} |||| → |||| 2 o {*} |||| → || || |||| Duct Shield Cooler |||| 2 o |||| 2 x {*} |||| 2 o {*} |||| → |||| → || || |||| Radiation Shield Cooler |||| 2 x |||| → |||| → |||| → |||| 2 o {*} || || |||| Payload Cooler |||| 2 x |||| → |||| → |||| → |||| → || || |||| FFUs |||| ??/24 |||| → |||| → |||| → |||| → || || |||| KAOCHs |||| zero |||| → |||| → |||| → |||| → || |
| Line 13: | Line 57: |
| * Go to [[http://172.16.32.60/kagra_mannual/img/commissioning_doc.png|Commissioning.Doc]]. * Select "SEMI AUTO ALIGNMENT" in Commissioning.Doc. * Select "! engage" in [[http://172.16.32.60/kagra_mannual/img/salignment.png|SEMI AUTO ALIGNMENT]]. |
|| |||| Items |||| O4a |||| 6/30 |||| 7/3 <<BR>> Cryocoolers ON ||||7/18 <<BR>> O4a Recovery|||| 7/27 <<BR>> Coolers On|| || IYC |||| TMP/Drys |||| 3 x |||| 3 o {*} |||| → |||| 3 x {*} |||| → || || |||| Ion Pump |||| 2 o |||| 2 x {*} |||| → |||| 2 o {*} |||| → || || |||| Duct Shield Cooler |||| 2 o |||| 2 x {*} |||| 2 o {*} |||| → |||| → || || |||| Radiation Shield Cooler |||| 2 x |||| → |||| → |||| → |||| 2 o {*} || || |||| Payload Cooler |||| 2 x |||| → |||| → |||| → |||| → || || |||| FFUs |||| ??/24 |||| → |||| → |||| → |||| → || || |||| KAOCHs |||| zero |||| → |||| → |||| → |||| → || |
| Line 17: | Line 66: |
| * ''' X arm GR alignment (ITMY misalign).''' | || |||| Items |||| O4a |||| 6/30 ||||7/18 <<BR>> O4a Recovery|| || IXA |||| TMP/Drys |||| 1x |||| → |||| 1o {*} || || |||| FFUs |||| ??/10 |||| → |||| → || |
| Line 19: | Line 70: |
| * Go to [[http://172.16.32.60/kagra_mannual/img/guardian_overview.png|Guardian Overview]]. * Select "VIS_ITMY" in Guardian Overview. * Select "request [All]" in [[http://172.16.32.60/kagra_mannual/img/guard-VIS_ITMY_MAIN.png|VIS_ITMY]]. * Select "Misaligned" in [[http://172.16.32.60/kagra_mannual/img/guard-VIS_ITMY_STATES.png|All]]. |
|| |||| Items |||| O4a |||| 6/30 ||||7/18 <<BR>> O4a Recovery|| || IYA |||| TMP/Drys |||| 1x |||| 1o {*} |||| → || || |||| FFUs |||| ??/10 |||| → |||| → || |
| Line 24: | Line 74: |
| * ''' X arm GR alignment (Resonate GR).''' | || |||| Items |||| O4a |||| 6/30 |||| |||| 7/11 <<BR>> dehumidifier change |||| 7/16 |||| 7/18 <<BR>> O4 recovery |||| 7/28~30 |||| 8/2~4 |||| 9/25 |||| 10/10 || || IXV |||| Air conditioner |||| x (weak, 20C) |||| o (weak, 20C) {*} |||| → |||| → |||| → |||| x (weak, 20C) {*} |||| → |||| x (weak, 20C) {*} |||| x (strong, 20C) {*} |||| → || || |||| Delonghi Heater |||| x |||| o L4 {*} |||| |||| o L3 {*} |||| o L4 {*} |||| x {*} |||| o L1 {*} |||| x {*} |||| → |||| o L3 {*} || || |||| Ceiling Lights |||| o |||| → |||| |||| → |||| → |||| → |||| x {*} |||| → |||| → |||| → || || |||| TMP/Drys |||| 1x |||| 1o {*} |||| |||| → |||| → |||| 1x {*} |||| → |||| → |||| → |||| 1o {*} || || |||| Ion Pump |||| 1o |||| 1x {*} |||| |||| → |||| → |||| 1o {*} |||| → |||| → |||| → |||| 1x {*} || || |||| FFUs |||| 2 |||| → |||| |||| → |||| → |||| → |||| → |||| → |||| 1 |||| 2 || || |||| Dehumidifier |||| o |||| → |||| |||| → |||| → |||| → |||| → |||| → |||| → |||| → || || |||| Items |||| O4a |||| 6/30 |||| 7/1 |||| 7/4 |||| 7/10 |||| 7/11 |||| 7/16 |||| 7/18 <<BR>> O4 recovery |||| 7/23 || || IYV |||| Air conditioner |||| o (weak, 20C) |||| → |||| → |||| → |||| → |||| → |||| → |||| → |||| → || || |||| Delonghi Heater |||| o L4 |||| o L2 {*} |||| o L1 {*} |||| o L2 {*} |||| x {*} |||| o L1 {*} |||| o L3 {*} |||| o L4 {*} |||| o L5 {*} || || |||| Ceiling Lights |||| o |||| → |||| → |||| → |||| → |||| → |||| → |||| → |||| → || || |||| TMP/Drys |||| 1x |||| o {*} |||| → |||| → |||| → |||| → |||| → |||| 1x {*} |||| → || || |||| Ion Pump |||| 1o |||| x {*} |||| → |||| → |||| → |||| → |||| → |||| 1o {*} |||| → || || |||| FFUs |||| 2 |||| → |||| → |||| → |||| → |||| → |||| → |||| → |||| → || || |||| Dehumidifier |||| o |||| → |||| → |||| → |||| → |||| → |||| → |||| → |||| → || === EX === |
| Line 26: | Line 94: |
| * Go to [[http://172.16.32.60/kagra_mannual/img/guardian_overview.png|Guardian Overview]]. * Select "XARM" in Guardian Overview. * Select "request [All]" in [[http://172.16.32.60/kagra_mannual/img//GRD-XARM_MAIN.png|XARM]]. * Select "Misaligned" in [[http://172.16.32.60/kagra_mannual/img/GRD-XARM_STATES.png|All]]. * You can see [[http://172.16.32.60/kagra_mannual/img/AOS-TMSX_GR_PDA1_OUTPUT.png|K1:AOS-TMSX_GR_PDA1_OUTPUT]] enhancement. |
|| |||| Items |||| O4a |||| 7/27 <<BR>> Coolers On |||| 8/13 <<BR>> TMPs on Ion off |||| 10/10 <<BR>> 4 cryocoolers operation || || EX 1F |||| Air conditioner 1 |||| x |||| o <<BR>> (weak, 22.5C) {*} |||| o <<BR>> (Strongest, 22.5C) {*}|||| o <<BR>> (Strong, 22.5C) {*}|| || |||| Air conditioner 2 |||| x |||| → |||| o <<BR>> (strong, 22.5C) {*} |||| o <<BR>> (Weak , 21.0C) {*}|| || |||| Ceiling Lights |||| 0/1 |||| → |||| → |||| → || || |||| Sunrise Heater |||| x |||| o L3 {*} |||| o L1 {*} |||| x || |
| Line 32: | Line 100: |
| * ''' X arm GR alignment (Check spot position).''' | || |||| Items |||| O4a |||| 7/27 <<BR>> Coolers On|||| 8/13 <<BR>> TMPs on Ion off |||| 10/10 <<BR>> 4 cryocoolers operation || || EXC |||| TMP/Drys |||| 4x |||| → |||| 4o |||| → || || |||| Ion Pump |||| 2o |||| → |||| 2x |||| → || || |||| Duct Shield Cooler |||| 2o |||| → |||| → |||| → || || |||| Radiation Shield Cooler |||| 2o |||| → |||| → |||| → || || |||| Payload Cooler |||| 2x |||| 2o {*} |||| → |||| 2x || || |||| FFUs |||| ??/24 |||| → |||| → |||| → || || |||| KAOCHs |||| zero |||| → |||| → |||| → || |
| Line 34: | Line 109: |
| * Go to [[http://172.16.32.60/kagra_mannual/img/commissioning_doc.png|Commissioning.Doc]]. * Select CAMERA. * Select "TCAM Comm Mode" in [[http://172.16.32.60/kagra_mannual/img/IFO_CAM.png|CAMERA]]. * Select "X_end_TCAM Commissioning mode start in [[http://172.16.32.60/kagra_mannual/img/CAL_TCAM.png|TCAM Comm Mode]]". * access [[http://172.16.33.39/vacuum|http://172.16.33.39/vacuum]] for ETMX Spot Monitoring. * access "! Tcam IX" for ITMX Spot Monitoring in [[http://172.16.32.60/kagra_mannual/img/IFO_CAM.png|CAMERA]]. |
|| |||| Items |||| O4a |||| ? |||| || || EXA |||| TMP/Drys |||| 1x |||| 1o |||| || || |||| Ion Pump |||| 1o |||| → |||| || || |||| FFUs |||| 1/10 |||| → |||| || || |||| Ceiling Lights |||| 1/1 |||| → |||| || |
| Line 41: | Line 115: |
| * ''' X arm GR alignment (PR3 Dithering).''' | || |||| Items |||| O4a |||| 8/13 <<BR>> TMPs on Ion off |||| 9/?? <<BR>> Warmup EXC || || EXV |||| Air conditioner |||| x |||| → |||| o <<BR>> (weak, 22.5C) {*} || || |||| Delongho Heater |||| o L3 |||| x {*} |||| o L1 || || |||| Ceiling Lights |||| 0/1 |||| → |||| → || || |||| TMP/Drys |||| 1x |||| 1o |||| → || || |||| Ion Pump |||| 1o |||| 1x |||| → || || |||| FFUs |||| 1 |||| → |||| → || || |||| Door |||| closed |||| open with a circulator |||| open with a circulator || |
| Line 43: | Line 124: |
| * Go to [[http://172.16.32.60/kagra_mannual/img/guardian_overview.png|Guardian Overview]]. * Select "XARM" in Guardian Overview. * Select "request [All]" in [[http://172.16.32.60/kagra_mannual/img/GRD-XARM_MAIN.png|XARM]]. * Select "MANUAL", then "ENGAGE_PR3_ADS" in [[http://172.16.32.60/kagra_mannual/img/GRD-XARM_STATES.png|All]]. |
=== EY === |
| Line 48: | Line 126: |
| * ''' X arm GR alignment (find good FP axis & PR3 P/Y).''' | || |||| Items |||| O4a |||| 6/29 |||| 7/3 |||| 7/13 |||| 7/18 <<BR>> O4a recovery|||| 7/27 <<BR>> Coolers On|||| 8/7 || || EY 1F |||| Air conditioner |||| x |||| → |||| → |||| → |||| → |||| → |||| → || || |||| Ceiling Lights |||| 1/1 |||| → |||| → |||| → |||| → |||| → |||| → || || |||| Delonghi Heater 1 |||| o L5 |||| o L2 {*} |||| o L1 {*} |||| o L2 {*} |||| o L5 {*} |||| o L4 {*} |||| o L3 {*} || || |||| Sunrise Heater 1 |||| o L3 |||| o L1 {*} |||| → |||| → |||| o L3 {*} |||| → |||| → || || |||| Sunrise Heater 2 |||| o L3 |||| o L1 {*} |||| → |||| → |||| o L3 {*} |||| → |||| → || |
| Line 50: | Line 133: |
| * Go to [[http://172.16.32.60/kagra_mannual/img/commissioning_doc.png|Commissioning.Doc]]. * Select "ALL VIS" in Commissioning.Doc. * Select "CRY-P" for both ITMX and ETMX in [[http://172.16.32.60/kagra_mannual/img/VIS_ALL.png|ALL VIS]]. * Select "OL SETPOINT" for ITMX and ETMX in [[http://172.16.32.60/kagra_mannual/img/CRY_CUST_TYPEA_OVERVIEW.png|CRY-P]]. * You can find for both ITMX and ETMX. Right click on [[http://172.16.32.60/kagra_mannual/img/CRY_CUST_TYPEA_MN_OLSET.png|slide bar]] and select “-1” as an increment. Never select large increment. * Adjust (IE)TMX alignment to lead their spots on both (IE)TMX to be around center. Ideally, K1:AOS-TMSX_GR_PDA1_OUTPUT should be maximized. *Or, Maximize K1:AOS-TMSX_GR_PDA1_OUTPUT by adjusting, firstly Yaw of IETMX and secondly Pitch. 1. Remember the value of [[http://172.16.32.60/kagra_mannual/img/AOS-TMSX_GR_PDA1_OUTPUT.png|K1:AOS-TMSX_GR_PDA1_OUTPUT]] (assuming VtmsxGR-0). * Anyway, move Yaw/ETMX in one direction until you observe slight reduction of VtmsxGR-0. * Move Yaw/ITMX in both direction to find max of VtmsxGR. * (4-1) If you can find better VtmsxGR than Vtmsxgr-0, it means your selection for ETMX actuation is good direction. (4-2) If worse, bad direction. * If good, repeat (2) (3) until you encounter (4-2). If bad, select opposite actuation then repeat (2)(3) until you encounter (4-2) again. * If you find max point, perform (1)~(5) for Pitch/(IE)TMX. (1)~(6) is regarded as one “set” optimization.Ideally, it is better to perform 2 sets for each Yaw/Pitch. |
|| |||| Items |||| O4a |||| 6/29 |||| 7/3 |||| 7/18 <<BR>> O4a recovery|||| 7/27 <<BR>> Coolers On|| || EYC |||| TMP/Drys |||| 4x |||| 3o, 1x {*} |||| → |||| 4x {*} |||| → || || |||| Ion Pump |||| 2o |||| 2x {*} |||| → |||| 2o {*} |||| → || || |||| Duct Shield Cooler |||| 2o |||| 2x {*} |||| 2o {*} |||| → |||| → || || |||| Radiation Shield Cooler |||| 2x |||| → |||| → |||| → |||| 2o {*} || || |||| Payload Cooler |||| 2x |||| → |||| → |||| → |||| → || || |||| FFUs |||| 13/24 |||| → |||| → |||| → |||| → || || |||| KAOCHs |||| zero |||| → |||| → |||| → |||| → || |
| Line 66: | Line 142: |
| * ''' X arm FP axis is established and PR3 P/Y is fixed.''' | || |||| Items |||| O4a |||| 6/29 |||| || || EYA |||| TMP/Drys |||| 1x |||| 1o {*} |||| || || |||| FFUs |||| 5/10 |||| 2/10 {*} |||| || || |||| Ceiling Lights |||| 1/1 |||| → |||| || |
| Line 68: | Line 147: |
* '''X arm GR alignment (Record good TMSX).''' * Go to [[http://172.16.32.60/kagra_mannual/img/commissioning_doc.png|Commissioning.Doc]]. * Select "SEMI AUTO ALIGNMENT" in Commissioning.Doc. * Push “! record TMS QPD" in [[http://172.16.32.60/kagra_mannual/img/salignment.png|SEMI AUTO ALIGNMENT]]. * '''X arm IR alignment (Resonate IR).''' * Go to [[http://172.16.32.60/kagra_mannual/img/guardian_overview.png|Guardian Overview]]. * Select "XARM" in Guardian Overview. * Select "request [All]" in [[http://172.16.32.60/kagra_mannual/img/GRD-XARM_MAIN.png|XARM]]. * Select "IR_LOCKED" in [[http://172.16.32.60/kagra_mannual/img/GRD-XARM_STATES.png|All]]. * You can see [[http://172.16.32.60/kagra_mannual/img/AOS-TMSX_GR_PDA1_OUTPUT.png|K1:AOS-TMSX_GR_PDA1_OUTPUT]] enhancement. * '''X arm IR alignment (PR2-IMMT2 alignment).''' * Go to [[http://172.16.32.60/kagra_mannual/img/commissioning_doc.png|Commissioning.Doc]]. * Select "ALL VIS" in Commissioning.Doc. * Select PR2 "OVERViEW" in [[http://172.16.32.60/kagra_mannual/img/VIS_ALL.png|ALL VIS]]. * Select "OPTIC SETPOINT" for PR2 in [[http://172.16.32.60/kagra_mannual/img/VIS_TYPEBP_OVERVIEW.png|OVERVIEW for PR2]]. * You can find for PR2. Right click on [[http://172.16.32.60/kagra_mannual/img/VIS_CUST_TYPEBP_TM_SETPOINT.png|slide bar]] and select “-1” as an increment. Never select large increment. * Select "IMMT2 in [[http://172.16.32.60/kagra_mannual/img/VIS_ALL.png|ALL VIS]]. * Select "OLSET OPTIC" for IMMT2. in [[http://172.16.32.60/kagra_mannual/img/VIS_CUST_TYPEC_OVERVIEW.png for IMMT2]]. * You can find for IMMT2. Right click on [[http://172.16.32.60/kagra_mannual/img/VIS_CUST_TYPEC_TM_OLSET.png|slide bar]] and select “-1” as an increment. Never select large increment. * Maximize K1:AOS-TMSX_IR_PDA1_OUTPUT by adjusting, firstly Yaw of PR2/IMMT2 and secondly Pitch. 1. Remember the value of [[http://172.16.32.60/kagra_mannual/img/AOS-TMSX_GR_PDA1_OUTPUT.png|K1:AOS-TMSX_IR_PDA1_OUTPUT]] (assuming VtmsxIR-0). * Anyway, move Yaw/PR2 in one direction until you observe slight reduction of VtmsxIR-0. * Move Yaw/IMMT2 in both direction to find max of VtmsxIR. * (4-1) If you can find better VtmsxIR than VtmsxIR-0, it means your selection for PR2 actuation is good direction. (4-2) If worse, bad direction. * If good, repeat (2) (3) until you encounter (4-2). If bad, select opposite actuation then repeat (2)(3) until you encounter (4-2) again. * If you find max point, perform (1)~(5) forPitch/PR2/IMMT2. (1)~(6) is regarded as one “set” optimization.Ideally, it is better to perform 2 sets for each Yaw/Pitch. * '''X arm IR alignment (GR/IR resonance check).''' * '''X arm GR/IR alignment Established.''' * '''Y arm IR alignment Preparation.''' * '''Y arm IR alignment (Resonate IR).''' * '''Y arm IR alignment (Check spot position on ETMY).''' * '''Y arm IR align (Adjust BS for ETMY spot centering).''' * '''Y arm IR alignment (ITMY,ETMY alignment).''' * '''Y arm IR alignment (Check spot on ITMY).''' * '''Y arm IR alignment Established.''' * '''Y arm IR alignment (Record good TMSY).''' * '''Y arm IR alignment Established.''' * '''Y arm GR alignment (Resonate GR).''' * '''Y arm GR alignment (TMSY GR maximize with SR3).''' * '''Y arm GR/IR alignment Established.''' * '''FPMI Recovery (Exit from alignment mode).''' * '''FPMI Recovery (Align ITMX).''' * '''FPMI Recovery (Start FPMI).''' |
|| |||| Items |||| O4a |||| 6/29 |||| 7/18 <<BR>> O4a recovery ||||7/21||||7/27|| || EYV |||| Air conditioner |||| x |||| → |||| → |||| → |||| → || || |||| Sunrise Heater |||| o L2 |||| x {*} |||| o L2 {*} |||| o L3 {*} |||| o L2 {*} || || |||| Ceiling Lights |||| 0/1 |||| → |||| → |||| → |||| → || || |||| TMP/Drys |||| 1x |||| 1o {*} |||| 1x {*} |||| → |||| → || || |||| Ion Pump |||| 1o |||| 1x {*} |||| 1o {*} |||| → |||| → || || |||| FFUs |||| 1/10 |||| → |||| → |||| → |||| → || |
[1] Clean booth
[2] Heat Generators
Corner
Corner 1F |
Items |
O4a |
6/30 |
7/1 |
7/6~7 |
7/11 |
7/15 |
7/16 |
7/18 |
|||||||||
- cooler |
Precision Cooler |
o(19.00) |
→ |
o(23.50) |
o(20.00) |
→ |
→ |
→ |
o(19.00) |
|||||||||
|
Daikin Cooler MCF-C |
x |
→ |
→ |
→ |
→ |
→ |
→ |
→ |
|||||||||
|
Daikin Cooler BS-C |
x |
o |
→ |
→ |
→ |
→ |
→ |
x |
|||||||||
|
Daikin Cooler SR-C |
x |
→ |
→ |
→ |
→ |
→ |
→ |
→ |
|||||||||
|
Daikin Cooler IYC-C |
x |
→ |
→ |
→ |
→ |
→ |
→ |
→ |
|||||||||
- light |
Ceiling Lights A |
1/2 |
→ |
→ |
→ |
→ |
→ |
→ |
→ |
|||||||||
|
Ceiling Lights B |
1/2 |
→ |
→ |
→ |
→ |
→ |
→ |
→ |
|||||||||
|
Ceiling Lights C |
1/1 |
→ |
→ |
→ |
→ |
→ |
→ |
→ |
|||||||||
|
Ceiling Lights IXC |
1/2 |
→ |
→ |
→ |
→ |
→ |
→ |
→ |
|||||||||
|
Ceiling Lights IXA |
1/1 |
→ |
→ |
→ |
→ |
→ |
→ |
→ |
|||||||||
|
Ceiling Lights IYC |
1/2 |
→ |
→ |
→ |
→ |
→ |
→ |
→ |
|||||||||
|
Ceiling Lights IYA |
1/1 |
→ |
→ |
→ |
→ |
→ |
→ |
→ |
|||||||||
- heater |
Sunrise Heater BS |
x |
→ |
o L1 |
x |
→ |
→ |
o L1 |
x |
|||||||||
|
Sunrise Heater SR2 |
x |
→ |
o L1 |
x |
→ |
→ |
→ |
→ |
|||||||||
|
Sunrise Heater OMC |
x |
→ |
o L2 |
o L1 |
→ |
x |
→ |
→ |
|||||||||
|
Sunrise Heater PR2 |
x |
→ |
→ |
→ |
→ |
→ |
→ |
→ |
|||||||||
|
Sunrise Heater DGS |
x |
→ |
→ |
→ |
→ |
→ |
→ |
→ |
|||||||||
|
Delonghi Heater MCF |
o L2 |
x |
→ |
→ |
→ |
→ |
→ |
o L2 |
|||||||||
|
Sunrise Heater EXC-A |
o L3 |
→ |
→ |
→ |
x |
→ |
→ |
→ |
|||||||||
- ffu |
SR FFUs |
03/?? |
→ |
→ |
→ |
→ |
→ |
→ |
→ |
|||||||||
|
BS FFUs |
03/?? |
→ |
→ |
→ |
→ |
→ |
→ |
→ |
|||||||||
|
PR FFUs |
04/?? |
→ |
→ |
→ |
→ |
→ |
→ |
→ |
|||||||||
|
MCE FFUs |
01/16 |
→ |
→ |
→ |
→ |
→ |
→ |
→ |
|||||||||
- airdry |
IXC-A Air Dryer |
x |
o |
→ |
→ |
→ |
→ |
→ |
→ |
|||||||||
- Dehumid |
Mitsubishi IYC-C |
o |
→ |
→ |
→ |
→ |
→ |
→ |
→ |
|||||||||
|
Mitsubishi BS-C |
o |
→ |
→ |
→ |
→ |
→ |
→ |
→ |
|||||||||
|
Iris DGS-1 |
o |
→ |
→ |
→ |
→ |
→ |
→ |
→ |
|||||||||
|
Iris DGS-2 |
o |
→ |
→ |
→ |
→ |
→ |
→ |
→ |
|||||||||
|
Nakatomi BS |
o |
→ |
→ |
→ |
→ |
→ |
→ |
→ |
|||||||||
|
Items |
O4a |
6/30 |
|
||||
PSL Room |
Precision Cooler #1 |
o |
→ |
|
||||
|
Precision Cooler #2 |
x |
→ |
|
||||
|
Items |
O4a |
6/30 |
7/3 |
7/18 |
7/27 |
||||||
IXC |
TMP/Drys |
3 x |
3 o |
→ |
3 x |
→ |
||||||
|
Ion Pump |
2 o |
2 x |
→ |
2 o |
→ |
||||||
|
Duct Shield Cooler |
2 o |
2 x |
2 o |
→ |
→ |
||||||
|
Radiation Shield Cooler |
2 x |
→ |
→ |
→ |
2 o |
||||||
|
Payload Cooler |
2 x |
→ |
→ |
→ |
→ |
||||||
|
FFUs |
??/24 |
→ |
→ |
→ |
→ |
||||||
|
KAOCHs |
zero |
→ |
→ |
→ |
→ |
||||||
|
Items |
O4a |
6/30 |
7/3 |
7/18 |
7/27 |
||||||
IYC |
TMP/Drys |
3 x |
3 o |
→ |
3 x |
→ |
||||||
|
Ion Pump |
2 o |
2 x |
→ |
2 o |
→ |
||||||
|
Duct Shield Cooler |
2 o |
2 x |
2 o |
→ |
→ |
||||||
|
Radiation Shield Cooler |
2 x |
→ |
→ |
→ |
2 o |
||||||
|
Payload Cooler |
2 x |
→ |
→ |
→ |
→ |
||||||
|
FFUs |
??/24 |
→ |
→ |
→ |
→ |
||||||
|
KAOCHs |
zero |
→ |
→ |
→ |
→ |
||||||
|
Items |
O4a |
6/30 |
7/18 |
||||
IXA |
TMP/Drys |
1x |
→ |
1o |
||||
|
FFUs |
??/10 |
→ |
→ |
||||
|
Items |
O4a |
6/30 |
7/18 |
||||
IYA |
TMP/Drys |
1x |
1o |
→ |
||||
|
FFUs |
??/10 |
→ |
→ |
||||
|
Items |
O4a |
6/30 |
|
7/11 |
7/16 |
7/18 |
7/28~30 |
8/2~4 |
9/25 |
10/10 |
|||||||||||
IXV |
Air conditioner |
x (weak, 20C) |
o (weak, 20C) |
→ |
→ |
→ |
x (weak, 20C) |
→ |
x (weak, 20C) |
x (strong, 20C) |
→ |
|||||||||||
|
Delonghi Heater |
x |
o L4 |
|
o L3 |
o L4 |
x |
o L1 |
x |
→ |
o L3 |
|||||||||||
|
Ceiling Lights |
o |
→ |
|
→ |
→ |
→ |
x |
→ |
→ |
→ |
|||||||||||
|
TMP/Drys |
1x |
1o |
|
→ |
→ |
1x |
→ |
→ |
→ |
1o |
|||||||||||
|
Ion Pump |
1o |
1x |
|
→ |
→ |
1o |
→ |
→ |
→ |
1x |
|||||||||||
|
FFUs |
2 |
→ |
|
→ |
→ |
→ |
→ |
→ |
1 |
2 |
|||||||||||
|
Dehumidifier |
o |
→ |
|
→ |
→ |
→ |
→ |
→ |
→ |
→ |
|||||||||||
|
Items |
O4a |
6/30 |
7/1 |
7/4 |
7/10 |
7/11 |
7/16 |
7/18 |
7/23 |
||||||||||
IYV |
Air conditioner |
o (weak, 20C) |
→ |
→ |
→ |
→ |
→ |
→ |
→ |
→ |
||||||||||
|
Delonghi Heater |
o L4 |
o L2 |
o L1 |
o L2 |
x |
o L1 |
o L3 |
o L4 |
o L5 |
||||||||||
|
Ceiling Lights |
o |
→ |
→ |
→ |
→ |
→ |
→ |
→ |
→ |
||||||||||
|
TMP/Drys |
1x |
o |
→ |
→ |
→ |
→ |
→ |
1x |
→ |
||||||||||
|
Ion Pump |
1o |
x |
→ |
→ |
→ |
→ |
→ |
1o |
→ |
||||||||||
|
FFUs |
2 |
→ |
→ |
→ |
→ |
→ |
→ |
→ |
→ |
||||||||||
|
Dehumidifier |
o |
→ |
→ |
→ |
→ |
→ |
→ |
→ |
→ |
||||||||||
EX
|
Items |
O4a |
7/27 |
8/13 |
10/10 |
|||||
EX 1F |
Air conditioner 1 |
x |
o |
o |
o |
|||||
|
Air conditioner 2 |
x |
→ |
o |
o |
|||||
|
Ceiling Lights |
0/1 |
→ |
→ |
→ |
|||||
|
Sunrise Heater |
x |
o L3 |
o L1 |
x |
|||||
|
Items |
O4a |
7/27 |
8/13 |
10/10 |
|||||
EXC |
TMP/Drys |
4x |
→ |
4o |
→ |
|||||
|
Ion Pump |
2o |
→ |
2x |
→ |
|||||
|
Duct Shield Cooler |
2o |
→ |
→ |
→ |
|||||
|
Radiation Shield Cooler |
2o |
→ |
→ |
→ |
|||||
|
Payload Cooler |
2x |
2o |
→ |
2x |
|||||
|
FFUs |
??/24 |
→ |
→ |
→ |
|||||
|
KAOCHs |
zero |
→ |
→ |
→ |
|||||
|
Items |
O4a |
? |
|
||||
EXA |
TMP/Drys |
1x |
1o |
|
||||
|
Ion Pump |
1o |
→ |
|
||||
|
FFUs |
1/10 |
→ |
|
||||
|
Ceiling Lights |
1/1 |
→ |
|
||||
|
Items |
O4a |
8/13 |
9/?? |
||||
EXV |
Air conditioner |
x |
→ |
o |
||||
|
Delongho Heater |
o L3 |
x |
o L1 |
||||
|
Ceiling Lights |
0/1 |
→ |
→ |
||||
|
TMP/Drys |
1x |
1o |
→ |
||||
|
Ion Pump |
1o |
1x |
→ |
||||
|
FFUs |
1 |
→ |
→ |
||||
|
Door |
closed |
open with a circulator |
open with a circulator |
||||
EY
|
Items |
O4a |
6/29 |
7/3 |
7/13 |
7/18 |
7/27 |
8/7 |
||||||||
EY 1F |
Air conditioner |
x |
→ |
→ |
→ |
→ |
→ |
→ |
||||||||
|
Ceiling Lights |
1/1 |
→ |
→ |
→ |
→ |
→ |
→ |
||||||||
|
Delonghi Heater 1 |
o L5 |
o L2 |
o L1 |
o L2 |
o L5 |
o L4 |
o L3 |
||||||||
|
Sunrise Heater 1 |
o L3 |
o L1 |
→ |
→ |
o L3 |
→ |
→ |
||||||||
|
Sunrise Heater 2 |
o L3 |
o L1 |
→ |
→ |
o L3 |
→ |
→ |
||||||||
|
Items |
O4a |
6/29 |
7/3 |
7/18 |
7/27 |
||||||
EYC |
TMP/Drys |
4x |
3o, 1x |
→ |
4x |
→ |
||||||
|
Ion Pump |
2o |
2x |
→ |
2o |
→ |
||||||
|
Duct Shield Cooler |
2o |
2x |
2o |
→ |
→ |
||||||
|
Radiation Shield Cooler |
2x |
→ |
→ |
→ |
2o |
||||||
|
Payload Cooler |
2x |
→ |
→ |
→ |
→ |
||||||
|
FFUs |
13/24 |
→ |
→ |
→ |
→ |
||||||
|
KAOCHs |
zero |
→ |
→ |
→ |
→ |
||||||
|
Items |
O4a |
6/29 |
|
||||
EYA |
TMP/Drys |
1x |
1o |
|
||||
|
FFUs |
5/10 |
2/10 |
|
||||
|
Ceiling Lights |
1/1 |
→ |
|
||||
|
Items |
O4a |
6/29 |
7/18 |
7/21 |
7/27 |
||||||
EYV |
Air conditioner |
x |
→ |
→ |
→ |
→ |
||||||
|
Sunrise Heater |
o L2 |
x |
o L2 |
o L3 |
o L2 |
||||||
|
Ceiling Lights |
0/1 |
→ |
→ |
→ |
→ |
||||||
|
TMP/Drys |
1x |
1o |
1x |
→ |
→ |
||||||
|
Ion Pump |
1o |
1x |
1o |
→ |
→ |
||||||
|
FFUs |
1/10 |
→ |
→ |
→ |
→ |
||||||